全国服务热线
13953181568
  • 新闻中心

    NEWSCENTER

    济南市防火卷帘门齿轮传动安裝方式

    时间:2019-09-27

    防火卷帘门的齿轮传动是由一条直徑为165(或114)的圆钢管组成,两边封住电焊焊接上卷帘门电机档板的轴把,与防火安全电动机就组成了齿轮传动,全部防火卷帘门的帘体就卷在这里套齿轮传动上。这套设备在安裝的那时候必须留意下列好多个难题。

    The gear drive of fire-proof rolling shutter door is composed of a circular steel tube with a diameter of 165 (or 114). The shaft handle of the motor baffle of the upper rolling shutter door is sealed and welded on both sides, and the gear drive is composed of the fire-proof safety motor. All the curtain bodies of fire-proof rolling shutter door are rolled up on the gear drive of the upper rolling shutter door. When installing this equipment, we must pay attention to the following problems.

    防火卷帘门齿轮传动安裝前,先将槽板定下方位放到秘药上,再把4-6片帘板放到槽板上并卷紧在秘药上川细铁丝扎牢。

    Before installing the gear transmission of fire-proof rolling shutter door, first set the groove plate in the lower position on the secret medicine, then put 4-6 pieces of curtain plate on the groove board and tighten the fine wire on the secret medicine.

    起吊防火卷帘门齿轮传动,必须要安全提示,设专职人员指挥者、人字梯、钢管脚手架、手动葫芦必须历经查验。安裝时先将套上滚动轴承及座的光轴塞进卷轴端孔中,指向部位后将滚动轴承固定不动地脚螺栓扭紧。

    The gear transmission of hoisting fire-proof rolling shutter door must be given safety warning, and the installation of full-time personnel commanders, ladders, steel pipe scaffolding and manual hoists must undergo inspection. Firstly, the optical axle with rolling bearings and pedestals is inserted into the end hole of the reel, and then the fixed foot bolt of the rolling bearing is tightened after pointing to the position.

    卷轴备好后,可上下挪动钢丝绳卷筒调整部位。一起用水平仪和水准管核查一下下秘药的水准。调节好后,光轴与秘药满焊固定不动,光轴与滚动轴承用支头螺丝固定不动。

    When the reel is ready, the adjusting part of the wire rope reel can be moved up and down. Check the level of the secret medicine with the level meter and the level tube together. After adjustment, the optical axle and the secret flux are fully welded and fixed, while the optical axle and the rolling bearing are fixed with the support screw.

    卷轴吊装时要特别注意不要碰坏卷在轴上的帘板,用钢丝 绳捆扎时要垫木板。

    When hoisting the reel, special attention should be paid not to break the curtain board rolled on the axle, but to pad the board when tied with wire rope.

    这就是为大伙儿详细介绍的有关安裝防火卷帘门齿轮传动的常见问题,防火卷帘门针对每个人都有很关键的功效,因此人们必须不可以忽视安裝那时候的一切关键点,防止防火卷帘门失去相对的运用。

    This is the common problem of installing gear transmission of fire-proof rolling shutter doors introduced in detail for everyone. Fire-proof rolling shutter doors have a key effect for everyone. Therefore, people must not ignore all the key points of installing fire-proof rolling shutter doors at that time, so as to prevent them from losing relative use./